ZEBRA​ ​Anode Conductive​ ​Paint

Description ZEBRA​ ​Anode​ ​is​ ​a​ ​patented,​ ​2-component,​ ​mineralic​ ​conductive​ ​paint​ ​specially​ ​designed​ ​for use​ ​as​ ​a​ ​long-lasting​ ​anode​ ​in​ ​the​ ​ZEBRA​ ​system​ ​for​ ​Cathodic​ ​Protection​ ​(CP)​ ​of​ ​steel​ ​in concrete.​ ​ZEBRA​ ​Anode​ ​is​ ​part​ ​of​ ​the​ ​ZEBRA​ ​system​ ​and​ ​the​ ​ones​ ​installing​ ​it​ ​are​ ​required​ ​to complete​ ​a​ ​training​ ​program. Areas​ ​of​ ​application The​ ​ZEBRA​ ​Anode,​ ​sealed​ ​with​ ​AHEAD​ ​Multiprimer​ ​is​ ​designed​ ​for​ ​use​ ​on​ ​car-parks,​ ​top​ ​of decks,​ ​slabs,​ ​columns,​ ​balconies,​ ​beams​ ​and​ ​soffits.​ ​Different​ ​areas​ ​of​ ​application​ ​requires different​ ​pre-​ ​and​ ​post-treatments​ ​in​ ​order​ ​to​ ​be​ ​a​ ​long​ ​lasting​ ​cathodic​ ​protection​ ​system. Preparations The​ ​concrete​ ​must​ ​be​ ​dry,​ ​free​ ​from​ ​paint,​ ​grease,​ ​oil,​ ​fat​ ​and​ ​other​ ​impurities.​ ​It​ ​must​ ​be suitable​ ​for​ ​the​ ​ZEBRA​ ​Anode​ ​to​ ​react​ ​with​ ​and​ ​adhere​ ​to.​ ​This​ ​is​ ​normally​ ​achieved​ ​by​ ​blastrac treatment,​ ​grinding​ ​or​ ​sandblasting​ ​the​ ​concrete​ ​subbase,​ ​if​ ​needed​ ​followed​ ​by​ ​removal​ ​of​ ​oil and​ ​grease.​ ​Concrete​ ​repairs​ ​must​ ​be​ ​properly​ ​executed​ ​and​ ​left​ ​to​ ​cure​ ​for​ ​specified​ ​time. Repair​ ​concrete​ ​must​ ​always​ ​be​ ​of​ ​“current​ ​open”​ ​types.​ ​It​ ​is​ ​strongly​ ​recommended​ ​to​ ​establish test​ ​fields​ ​of​ ​ZEBRA​ ​Anode​ ​and​ ​following​ ​layers​ ​on​ ​both​ ​undamaged​ ​concrete​ ​and​ ​repaired concrete.Test​ ​fields​ ​are​ ​made​ ​to​ ​check​ ​anode​ ​adhesion​ ​and​ ​anode​ ​coating​ ​thickness (measured​ ​by​ ​electrical​ ​resistance).​ ​The​ ​ZEBRA​ ​Anode​ ​shall​ ​be​ ​fully​ ​hardened​ ​before application​ ​of​ ​AHEAD​ ​Multiprimer​ ​and​ ​wearing​ ​courses.​ ​If​ ​not,​ ​the​ ​resistivity​ ​will​ ​be​ ​too​ ​high, and​ ​the​ ​adhesion​ ​to​ ​low.​ ​In​ ​cases​ ​where​ ​hardening​ ​does​ ​not​ ​progress​ ​satisfactorily,​ ​the​ ​relative humidity​ ​in​ ​the​ ​environment​ ​needs​ ​to​ ​be​ ​reduced. Mixing Mixing​ ​ratio​​ ​ ​ ​A-comp:​ ​ ​ ​ ​ ​ ​ ​ ​7,3​ ​kg B-comp:​ ​ ​ ​ ​ ​ ​ ​ ​2,7​ ​kg Total​ ​weight:​ ​10​ ​kg

Mix​ ​component​ ​B​ ​with​ ​component​ ​A​ ​for​ ​approximately​ ​3​ ​minutes​ ​with​ ​a​ ​powerful​ ​hand-held​ ​mixer.​ ​If needed,​ ​continue​ ​mixing​ ​until​ ​the​ ​product​ ​is​ ​completely​ ​homogenous​ ​and​ ​without​ ​lumps. As​ ​soon​ ​as​ ​the​ ​mixing​ ​is​ ​complete​ ​the​ ​curing​ ​will​ ​start.

HS​ ​export​ ​code:​ ​3209​ ​9000

Zebra​ ​Anode,​ ​Rev​ ​3​ ​-​ ​September​ ​2016 Page​ ​1​ ​of​ ​3

Application Apply​ ​with​ ​a​ ​roller​ ​or​ ​airless​ ​spray​ ​in​ ​ONE​ ​coat. The​ ​optimal​ ​consumption​ ​is​ ​0.30-0.35​ ​kg/pr.​ ​m2​ Min.​ ​temp​ ​ ​10°C​ ​on​ ​concrete​ ​surface Max.​ ​temp​ ​30°C​ ​on​ ​concrete​ ​surface Pot​ ​life After​ ​mixing,​ ​1​ ​hour​ ​at​ ​25°C. Curing Touch​ ​dry​ ​at​ ​25°C:​ ​after​ ​approx.​ ​30​ ​min. Drying​ ​time​ ​before​ ​further​ ​covering:​ ​2​ ​-​ ​7​ ​days. Full​ ​strength​ ​is​ ​achieved​ ​after​ ​14​ ​days,​ ​dependent​ ​of​ ​temperature​ ​and​ ​relative​ ​humidity. Cleaning​ ​and​ ​storage Rinse​ ​all​ ​used​ ​tools​ ​with​ ​freshwater​ ​before​ ​the​ ​Anode​ ​paint​ ​dries. ZEBRA​ ​Anode​ ​paint​ ​is​ ​water-soluble​ ​when​ ​wet,​ ​but​ ​not​ ​when​ ​dried​ ​and​ ​cured. ZEBRA​ ​Anode​ ​paint​ ​must​ ​be​ ​stored​ ​frost​ ​free. Shelf​ ​life​ ​is​ ​12​ ​months​ ​for​ ​both​ ​components. Properties The​ ​ZEBRA​ ​Anode​ ​material​ ​is​ ​based​ ​upon​ ​silicate​ ​technology​ ​combined​ ​with​ ​additives​ ​and catalysts​ ​to​ ​ensure​ ​stable​ ​and​ ​longtime​ ​functionality​ ​as​ ​a​ ​CP​ ​anode.​ ​It​ ​maintains​ ​anode​ ​stability which​ ​gives​ ​effective,​ ​long​ ​term​ ​corrosion​ ​protection​ ​of​ ​the​ ​embedded​ ​steel.​ ​When​ ​protected​ ​by AHEAD​ ​EC​ ​components,​ ​the​ ​alkalinity​ ​level​ ​in​ ​the​ ​components​ ​within​ ​EC​ ​protection​ ​materials contributes​ ​to​ ​an​ ​increased​ ​alkalinity​ ​at​ ​the​ ​anode-concrete​ ​interface​ ​and​ ​to​ ​allow​ ​electrical transfer​ ​resistance​ ​towards​ ​the​ ​concrete,​ ​and​ ​to​ ​reduce​ ​acidification​ ​over​ ​time.​ ​The​ ​ZEBRA Anode​ ​and​ ​its​ ​protection​ ​materials​ ​will​ ​ensure​ ​a​ ​good​ ​initial​ ​adhesion,​ ​and​ ​under​ ​correct​ ​usage operate​ ​trouble​ ​free​ ​for​ ​years​ ​to​ ​come. Adhesion​ ​and​ ​resistivity​ ​should​ ​be​ ​checked​ ​and​ ​approved​ ​by​ ​the​ ​supervisor,​ ​prior​ ​to​ ​main application. Color​ ​of​ ​the​ ​anode​ ​is​ ​dark​ ​gray. Safety​ ​instructions Always​ ​use​ ​proper​ ​personal​ ​protective​ ​equipment. Take​ ​care​ ​of​ ​proper​ ​ventilation​ ​during​ ​the​ ​installation. Technical​ ​data Component​ ​A: Component​ ​B: Pigment: Density: No.of​ ​layers: HS​ ​export​ ​code:​ ​3209​ ​9000

special​ ​silicate​ ​with​ ​additives alkaline​ ​Mg-carbonate graphite approx:​ ​1.33​ ​kg​ ​/​ ​dm​3 1

Zebra​ ​Anode,​ ​Rev​ ​3​ ​-​ ​September​ ​2016 Page​ ​2​ ​of​ ​3

Solid​ ​content: Material​ ​per​ ​m2​​ : Dry​ ​layer​ ​thickness: Adhesion​ ​strength: Electrical​ ​resistivity: Approx.​ ​pin-pin​ ​resistivity: Sheet​ ​resistance:

41​ ​%​ ​by​ ​weight 0,35​ ​kg/m​2​ ​ ​of​ ​concrete​ ​surface​ ​(structure​ ​dependent) approx.​ ​150​ ​microns >1​ ​N/mm​2​,​ ​after​ ​full​ ​curing​ ​on​ ​good​ ​concrete <1​ ​Ohm​ ​cm​ ​(after​ ​4​ ​days) <100​ ​Ohm <50​ ​Ohm​ ​square

Max.voltage: Max.current​ ​density:

2.5​ ​V​ ​or​ ​less​ ​normally​ ​sufficient.​ ​Limited​ ​by​ ​acidification​ ​of​ ​concrete​ ​subbase. 20​ ​mA​ ​/​ ​m2​

HS​ ​export​ ​code:​ ​3209​ ​9000

Zebra​ ​Anode,​ ​Rev​ ​3​ ​-​ ​September​ ​2016 Page​ ​3​ ​of​ ​3

ZEBRA Anode

application of AHEAD Multiprimer and wearing courses. If not, the resistivity will be too high, and the ... of proper ventilation during the installation. Technical data.

1MB Sizes 1 Downloads 61 Views

Recommend Documents

Zebra Barcode scanner.pdf
... for Rough Manufacturing). 4,699.00. 3 years, exclude. cable and. accessories. Page 3 of 3. Main menu. Displaying Zebra Barcode scanner.pdf. Page 1 of 3.

Zebra Label printer ribbon.pdf
There was a problem previewing this document. Retrying... Download. Connect more apps... Try one of the apps below to open or edit this item. Main menu.

PINK ZEBRA SPRINKLES RECIPES.pdf
... it in your stash. * To add new recipes to this list OR to get updated copies, please email April at: ... 1/3 Farm House Cider. 1/3 Vanilla ... All American. 1/5 PZ1.

1508998183-zebra-finches-complete-keeping-healthy-isbn.pdf ...
1508998183-zebra-finches-complete-keeping-healthy-isbn.pdf. 1508998183-zebra-finches-complete-keeping-healthy-isbn.pdf. Open. Extract. Open with.

Buku manual daihatsu zebra 1.3
Buku manual daihatsu zebra 1.3. Buku manual daihatsu zebra 1.3. Open. Extract. Open with. Sign In. Main menu. Displaying Buku manual daihatsu zebra 1.3.

pdf-1327\be-my-baby-tonight-zebra-contemporary ... - Drive
Connect more apps... Try one of the apps below to open or edit this item. pdf-1327\be-my-baby-tonight-zebra-contemporary-romance-by-kasey-michaels.pdf.

Zebra-Deutsch-Polnisch-1-2-Schuljahr-bungsheft.pdf
Whoops! There was a problem loading more pages. Whoops! There was a problem previewing this document. Retrying... Download. Connect more apps... Try one of the apps below to open or edit this item. Zebra-Deutsch-Polnisch-1-2-Schuljahr-bungsheft.pdf.

pdf-1274\zebra-finches-barrons-complete-pet-owners-manuals ...
Try one of the apps below to open or edit this item. pdf-1274\zebra-finches-barrons-complete-pet-owners-manuals-paperback-by-hans-j-martin.pdf.

Male Agonistic Behaviour in Free-Living Zebra ... - Bentham Open
1,* and Harold L. Pratt, Jr. 2. 1Swiss Federal Institute of Technology; 2Center for Shark Research, Mote Marine Laboratory ... ages provide invaluable information about animal behaviour. However, these ..... Whitney NM, Pratt HL Jr, Carrier JC.

Male Agonistic Behaviour in Free-Living Zebra ... - Bentham Open
Abstract: We analysed digital still photographs of two interacting free-living male zebra sharks. The recorded ... rich, Switzerland; Tel: +41-44-6345355; Fax: +41-44-6345351; E-mail: ... the diver, and no other shark species and/or conspecifics.

pdf-11148\2011-scotland-national-geographic-calendar-by-zebra ...
Connect more apps... Try one of the apps below to open or edit this item. pdf-11148\2011-scotland-national-geographic-calendar-by-zebra-publishing-corp.pdf.